Dodge Ram 1500 2500 3500 4000 Ram Pickup 2004 Service & Repair Manual

Dodge Ram 1500 2500 3500 4000 Ram Pickup 2004 Service & Repair Manual

Loaded with illustrations, instructions, photos, and diagrams, complete to service and repair your vehicle. Read and print pages directly from the CD or copy the entire manual to your hard drive.

2895 Pages

 

Models covered :

All 2004 Dodge RAM 

Ram Pickup 1500 4 X 2

Ram Pickup 1500 4 X 4

Ram Pickup 2500 4 X 2

Ram Pickup 2500 4 X 4

Ram Pickup 3500 4 X 2

Ram Pickup 3500 4 X 4

 

Transmission:

DGT = 4–speed Automatic (46RE)

DG4 = 4–speed Automatic (45RFE)

DGP = 4–speed Automatic (47RE)

DG8 = 4–speed Automatic (48RE)

DDC = 5–speed Manual (NV3500)

DDP = 5–speed Manual (NV4500)

DEE = 6–speed Manual (NV5600)

 

Engine:

3.7L 6 cyl. MPI Gasoline

4.7L 8 cyl. MPI Gasoline

5.7L 8 cyl. SMPI Gasoline

5.9L 6 cyl. Turbo Diesel

5.9L 6 cyl. Turbo Diesel High Output

8.0L 10 cyl. MPI Gasoline

5.9L 8 cyl. SMPI Gasoline Light Duty

 

 

MANUAL COVERS:

• Complete Engine Service + Auto & Manual Transmission
• Fuel System Service
• Factory Repair Procedures
• Wiring Diagrams
• Gearbox
• Exhaust System
• Suspension
• Fault Finding
• Clutch Removal and Installation
• Front Suspension
• Bodywork
• Gearbox Service, Removal and Installation
• Cooling System
• Detailed Specifications
• Transmission
• Factory Maintenance Schedules
• Electrics
• Engine Firing Order
• Brake Servicing Procedures
• U-Joint Service Procedures
• CV Joint Service Procedures
• Timing Chain Service
• Exhaust Service
• Abundant Illustrations
• Lots of pictures & diagrams

 

 

This manual contains :

Yaw Rate Sensor
Wiring Diagrams
Wire Harness Repair
Wiper Rubber
Wiper And Washer System
Wiper & Washer
Windshield Wiper Switch
Windshield Wiper Motor
Windshield Glass
Window Defogger System
Wheel And Tire System
Water Pump
Washer Nozzle
Valve Clearance
Transmission Wire
Transmission Valve Body
Transmission Revolution Sensor
Transmission Control Cable
Torque Converter Clutch
Tire & Wheel
Throttle Body
Thermostat
Supplemental Restraint System
Sun Roof System
Sun Roof
Steering System
Steering Sensor
Steering Column
Starting System
Starter Switch
Starter
Spiral Cable Sub
Speed Sensor Front
Skid Control Sensor
Side Turn Signal Lamp  y
Side Mudguard
Side Air Bag Sensor
Shift Lock System
Shift & Select Lever Shaft
Sfi System
Seat Position Air Bag Sensor
Seat Belt Warning System
Seat Belt
Seat
Roof Headlining
Roof Drip Side Finish Molding
Roof Antenna Pole Sub
Receiver Condenser
Rear Wiper Rubber
Rear Wiper Motor
Rear Wheel Alignment
Rear Suspension System
Rear Suspension
Rear Speaker
Rear Shock Absorber
Rear Seat Belt
Rear Door Window Frame Molding
Rear Door Glass Weather-strip
Rear Door
Rear Combination Lamp
Rear Coil Spring
Rear Bumper
Rear Brake
Rear Axle Hub
Rear Axle Beam
Radio Receiver
Radiator
Quarter Window
Pulley Compressor
Preparation
Power Window Control System
power Steering Link
Power Steering
Power Source
Power Mirror Control System
Power Door Lock Control System
Passenger Air Bag
Partial Engine
Park neutral Position Switch
Parking Brake Lever
Parking Brake Cable
Parking Brake
Output Shaft
Outer Rear View Mirror
Oil Pump
Oil Filter
Name Plate
Manual Transaxle System
Manual Transaxle Oil
Manual Transaxle
Maintenance
Lubrication System
Lighting System
License Plate Lamp
Knock Sensor
Introduction
Instrument Panel
Input Shaft
Inner Rear View Mirror
Ignition System
Horn Button
Horn
Hood
Heater Radiator
Heater Or Boost Ventilator Control
Heater & Air Conditioner
Headlamp Protector Retainer
Headlamp Dimmer Switch
Headlamp
Generator
Fuel Tank
Fuel System
Fuel Pump
Fuel Injector
Front Wheel Alignment
Front Suspension System
Front Suspension Arm
Front Suspension
Front Stabilizer Bar
Front Speaker
Front Shock Absorber
Front Seat Belt
Front Seat Airbag
Front Marker Lamp
Front Drive Shaft
Front Door Glass Weather-strip
Front Door
Front Differential Oil Seal
Front Bumper
Front Brake
Front Axle Hub
Floor Shift Parking Lock Cable
Floor Shift
Fender Panel Mudguard
Exhaust Pipe
Exhaust
Engine Mechanical
Engine Coolant
Engine Control System
Emission Control Systems
Drive Shaft
Drive Belt
Differential Case
Cylinder Head
Cylinder Head
Cylinder Block
Curtain Shield Air Bag
Cooling System
Cooling Fan System
Combination Meter
Clutch Unit
Clutch System
Clutch Start Switch
Clutch Release Cylinder
Clutch Pedal Sub
Clutch Master Cylinder
Cigarette Lighter
Charging System
Charcoal Canister
Chain Sub
Center Stop Lamp
Center Cluster Module Switch
Center Air Bag Sensor
Camshaft Position Sensor
Camshaft
Brake System
Brake Pedal
Brake Master Cylinder
Brake Fluid
Brake Booster
Brake Actuator
Body Repair
Back Door Glass
Back Door Garnish
Back Door
Automatic Transaxle Fluid
Automatic Transaxle
Audio & Visual System
Antenna Cord Sub
Amplifier Antenna
Air Conditioning System
Air Conditioning Blower
Air Conditioning Amplifier
Air Conditioner Refrigerant
Air Bag Sensor Rear
Air Bag Sensor Front

 

This manual is the same as the manual used by workshops. Service Manual contains detailed instructions and step by step diagrams for all workshop procedures.

 

Language: English 
Format: PDF – Indexed and Searchable

COMPATIBLE WITH ALL WINDOWS & MAC COMPUTERS 
(WINDOWS 11, WINDOWS 10, WINDOWS 8, WINDOWS 7, VISTA 32 and 64, XP, ME, 98, NT, 2000 ETC.) 

Windows/Mac/Tablet/Phone Friendly

32 / 64 bit